4R100 Transmission parts
Transmission general data
|Number of gears||Transmission Type||Drive||Torque (Nm)||ATF (full capacity) L||ATF (change) L||ATF type (recommended)|
The 4-speed automatic transmission 4R100\ E4OD for powerful RWD vehicles with engine capacity from 5 liters was produced by Ford since 1996.This transmission is a modification of its predecessor E4OD, which was used since 1989.It is tested, well-balanced and rare in repair transmission. Efficient and not complicated design of this transmission served as a basis for the following generation of the 5-speed automatic transmissions - 5R110W. (starting from 2003).
What are you looking for?
Overhaul Kit | Friction Kit | Friction | Steel Plate | Steel Kit | Band | Solenoid Kit | Solenoid EPC | Solenoid TCC | Pump | Shaft | Drum | Valve body | Torque converter | Hub | Piston | Piston Kit | Planetary Gear | Filter | Gasket | Bushing | Seal | Bearing | Pressure Plate | Stator | Differential | Retainer | Inhibitor Switch | Instruction manual | TOOLS & ACCESORIES | Sensor
Which cars run with this gearbox? CLICK
|Ford||ECONOLINE 150||1/98-04||4 SP RWD||V8 5.4L|
|Ford||ECONOLINE 250/250 SUPER DUTY||1/98-04||4 SP RWD||V8 5.4L 7.3L DIESEL V10 6.8L|
|Ford||ECONOLINE 350/350 SUPER DUTY||1/98-05||4 SP RWD||V8 5.4L 7.3L DIESEL V10 6.8L|
|Ford||EXCURSION||00-05||4 SP R/4WD||V8 5.4L 7.3L DIESEL V10 6.8L|
|Ford||EXPEDITION||1/98-02||4 SP R/4WD||V8 5.4L|
|Ford||F-150 /F-250||1/98-07||4 SP R/4WD||V8 5.4L 7.3L DIESEL V10 6.8L|
|Ford||F-350/350 SUPER DUTY||99-04||4 SP R/4WD||V8 5.4L 7.3L DIESEL V10 6.8L|
|Ford||F-450/550 SUPER DUTY||3/98-04||4 SP R/4WD||V8 7.3L DIESEL V10 6.8L|
|Lincoln||BLACKWOOD||2||4 SP RWD||V8 5.4L|
|Lincoln||NAVIGATOR||1/98-04||4 SP R/4WD||V8 5.4L|
Technical issues and repair guidelines
Problems with this transmission start with solenoids, reaching the end of their service life, or when the valve body gets clogged together with valves, transmitting the pressure in line. It leads to the burning of friction components or even drums.Filters for both modifications 4R100\ E4OD are the same and differ by high scoop.The kit of frictions gets fully replaced in case of burnt ATF.
In addtion to spare parts with rubber covered pistons, a typical repair order includes the brake band Intermediate (Direct, High/ Reverse). Seals of the pump and the input shaft are replaced in the course of repair of old cars.
Then transmission specialists usually deal with the following components:
- the drum Intermediate/ Overdrive Clutch
- Separator of the overrunning clutch Sprag, (INTERM).
- solenoids are replaced as a whole block.