4HP22 Transmission parts, repair guidelines, problems, manuals
Transmission general data
| Number of gears | Transmission Type | Drive | Torque (Nm) | ATF (full capacity) L | ATF (change) L | ATF type |
|---|---|---|---|---|---|---|
| 4 | AT | RWD | 400 | 9,3 | 4 | LT 71141 |
The 4-speed automatic transmission ZF 4HP22 was designed in the early 1980s for 2-3 liter diesel (rear-driven) car models. It has a "classic" engineering structure, ensuring not only high robustness, but also even wear-out of parts without obvious soft spots. The 4HP22 - 24 unit was used by all European automakers of high-priced and reliable cars: Audi, BMW, Jaguar etc. In terms of design, this transmission is similar to famous A4LD from Ford and A40-series from Toyota. The 4HP24 unit found application in 4WD models.
What are you looking for?
Overhaul Kit | Friction Kit | Friction | Steel Plate | Steel Kit | Band | Solenoid Kit | Solenoid EPC | Solenoid TCC | Pump | Shaft | Drum | Valve body | Torque converter | Hub | Piston | Piston Kit | Planetary Gear | Filter | Gasket | Bushing | Seal | Bearing | Pressure Plate | Stator | Differential | Retainer | Inhibitor Switch | Instruction manual | TOOLS & ACCESORIES | Sensor
-
-
- Oils, NS2, NS-2, ATF, Oil
- Bearings, brg, Mainbearing
- Cover Bolt, Cover Bolts, Mounting Bolt, Mounting Bolts, Pan Bolt, Pan Bolts, stud, studs, Split Pin
- Vents, Case Vent, Case Vent Valve, Vent Hose Connector, Vent, Plastic Breather
- Bushings, Bush,
- Input Carriers, Input Carrier, Carrier Assy, CARRIER-CR, CARRIER-MD,
- Casing, casings, cases
- Case Covers, Cover, Dust Cover,
- Circlips, Clip, Detent Cable Clip, Line Clip, Linkage Clip, Retainer Clip, Snap Ring, Snap Rings, Retaining Ring, Cover Retaining Ring, Retaining Ring, Circlip Kit, Kit Circlips, Kit Snap Ring, Kit Snap Ring,
- Connectors, loom
- Drain Plugs, Drain Bung
- Drums, Contender Drum, Drum with Bearing, Reverse Drum, Drum Part
- TCMs, transmission control module, TCU, TCM, Computer, Circuit Board, Control Module, Control Unit, Hardware
- Electrics, Electric, Electronic, Electronic Shift, Electronics, Pin Wiring, Relay Control Switch, Neutral Relay, Main Relay
- Filters, Filter Cartridges, Filter Cartridge, Oil Pan Filter, Inlet, Filter Kit
- Friction Discs, Frictions, fric, Friction Disc, Friction, Friction Plate, Friction Ring, fric., Clutch Plate, Friction Lining
- Friction kits, friction pack, friction set, High Energy Clutch Friction Module, Friction clutch
- Gaskets, gsk, gskt, , Cover Gasket, Cover Gaskets, Case Gasket, Case Gaskets, Filter Gasket,Filter Gaskets
- Gasket Pan, Pan Gaskets, Pan gasket, Filter Gasket,Filter Gaskets
- Governors
- loom, Harnesses, Line Connector, Wiring, Cover Wiring, Cable, Signal Cable, Cable, Power Cord
- Housings
- Hubs, Hub Insert
- Impellers
- Impeller Hubs
- Input Shafts, Shaft input, Shaft Input/Main, Inputshaft
- manuals, Technical manual, Repair manual, service manual, Manual, VIDEO & AUDIO, tapes
- Mounting Pad, Mounting Ring, Transmission Mount, Transmission Mounts, Mounting Rings, Mounting Pads
- o-ring, o ring, 0ring, 0-ring, 0 ring, ORing, Ring, O-Rings, o-ring, O'Ring
- Output Shafts, Carrier Output Shaft, SHAFT OUTPUT
- O/D,
- ohk, OHK kit, Overhauls, mok, Overhaul kit, Masterkit, Master kit, Master Overhaul, Repair package, Overhaul, Rebuild kit, Master Rebuild, Super Rebuild Bundle, Banner Kit, SUPER KIT, SUPERIOR KIT
- Pans, Crankcase, Oil Pan
- Piston Pins, Servo Pin, Piston Pin, Band Pin, Retaining Pin, Retaining Pins
- Pipes, Modulator Pipe, Inlet Pipe, feed Pipe, oil pipe
- Pistons, Apply Piston, Pack Piston, High Piston, Damper Piston, Piston Damper, Piston Plate, Interm. Servo Pist, Piston Seals, Piston Seal Ring, Piston Seal Rings, Piston Seal, Piston Cover, Piston Covers, Rear Servo, servo piston, Piston Retainer, Piston Retainers, Servo kit, Super Servo, servo, Shift Pison
- Pressure Plates, Apply Plate, Backing Plate, Backing Plates, Backplate, Ret Plate, Dish Plate, Press Plate
- Pumps, Rotor, Vane, Vanes, Kit Pump Vane/Ring
- Regulators, Main Pressure Regulator, Main Pressure Reg, Pressure Regulator, Forward Regulator, Secondary Regulator, Pressure Reg, Press Reg
- Retainers, Spring Retainer, Plug Retainer, Bearing Retainer
- Seals, Metal clad seal, Lip Seals, Connector Hole Seal, Lip Seal, Main Seal, Radial Lip Seal, Main Seal, Manual Seal, Oil Feed Seal, Side Cover Seal, Seal Cooler, Seal Oil Cooler, Case Seal
- Pump seal
- Cap,
- Seal Rings, Seal Ring, Sealing Rings, Piston Seal, S/Ring, SEALING RINGS S/Ring, Accumalator Seals
- Sensors
- solenoid, Shift Solenoid, Kickdown Solenoid, Control Solenoid Support, Solenoid Retainer, Interlock Solenoid, Solenoid Switch
- Speed Sensors, Output Sensor, Input sensor, Reluctor, Shaft Sensor, Speed Sender, Sensor Input, Sensor Output, Sensor Input / Output, TURBINE SPEED, INPUT SPEED, VEHICLE SPEED
- spragg, Sprags, Mechanical Diode, Sprag Assembly, Sprag Cartridge, One Way Clutches, One Way Clutch, Roller Clutches, Roller Clutch, Low/Rev Diode, Retaining Plates, Retaining Plate, Accordion Spring, OWC
- Springs, Wave Spring, Spring Adjuster, Spring Disc, Torsion Spring, Return Spring, Piston Spring, Damper Spring, Damper Springs, Control Spring, Detent Spring, Drum Spring, Limit Spring, Return Sprng, Diaphragm Springs, Diaphragm Spring
- Stators
- Stator Shafts, stator support shaft
- Steel Kits, Steel Set Kit, Steel Clutch Plate Kit, Steel kit, clutch steel, clutch steels, Steel set, steel pack, module kit, Steel Plate Clutch Kit, Steel Plate Kit, Steel Plate Module, Steel Plate Set, Steel Module
- Steel Plates, steel, Steels, steel disk
- Supports, Centre Supp Rebuilt, central support. support central
- Manifolds, Switch Manifold, Switch Manifolds, Pressure Switch Manifold, Pressure Switch Manifolds, Switch, Manifold
- Washer, Washers, T/Washers, Thrust Washers, Selective Washers, Kit Washer, Drive Sprockets, Driven Sprockets, Drive Sprocket, Thrust Kit, Washer kit,
- Tool kits, Alignments, Alignment, Reamers, Reamer, Tool kit, Tool, Pressure Gauge, Clutch Aligning Tool, Clutch Removal Tool, Clutch Tool Supplement, Kit Installer, Air Test Plate, ADJUSTMENT TOOL, Thread Tap, Remover
- converter, t.converter,
- Tubes, Oil Tube
- Throttle Valve, Timing Valve, Operating, Relief Valve, Safety Valve, Control Valve, AFL Valve, Limit Valve, Actuator Feed Limit Valve, AFL Valve
- VB plate, Valve body plates, Valve body plate, ValveBody, V/Body, valve-body, v body, v-body, v/b, Orifice, Hydraulic control unit, HCU
Technical issues and repair guidelines
The difference between 4HP22 and 4HP24 modifications lies in frictions and steel discs in packages. The modification with the valve body (type Е9) and 4 solenoids is the most common in repair, while earlier series with 5-solenoids in the valve body are considered to be a rarity.The ZF 4HP24 unit is a fail-safe and massive transmission, constructed with the help of high-quality materials, ensuring enhanced safety margin.
Repair procedures
Friction components of the Forward package are the first to get burnt because of intensive operation. The percentage of hard parts replacement and seals (separately) is quite low only in the overhaul kit (repair kit). It is common to replace worn-out pump housing bushing (covers – 17 mm), and less frequently bushings (13 mm) with the pump gasket and pump seal in the 4HP22/24 unit suffering from oil starvation. Land Rover’s oil pump gets out of service early because of contaminated fluid and long-term operation with a faulty torque converter. It is required to perform the torque converter repair together with the abovementioned procedure.The improper operation of clogged or worn-out solenoids and valve body is named as the main reason of oil starvation causing burning of the package Forward.
The replacement of solenoids is a scheduled procedure for old cars using this transmission. The problem of a dirty valve body is usually explained by worn-out locking clutch of the torque converter. If there are some delays with gears shifting, kicks or slippage in ZF 4HP22 with mileages above 200 thousand kilometers, then it signals that springs and solenoids cannot handle the dirt from frictions falling on valves. The minor overhaul prolongs the resource of this transmission for many years. It is suggested that the average resource of ZF4HP22 (4HP24) before the overhaul can reach up to 300 thousand kilometers, but it depends on the driving style “aggressiveness”.
Instruction manuals and useful links Suggest your link
| Link type | Source | Description |
|---|---|---|
| www.at-manuals.com | Scheme | |
| drive.google.com | Repair manual 4HP22 | |
| drive.google.com | Repair manual ZF 4HP24A |