722.7 Transmission parts, repair guidelines, problems, manuals
W5A180
Transmission general data
| Number of gears | Transmission Type | Drive | Torque (Nm) | ATF (full capacity) L | ATF (change) L | ATF type |
|---|---|---|---|---|---|---|
| 5 | AT | FWD | 205 | 6,3 | 3,3 | 236.12 |
What are you looking for?
Overhaul Kit | Friction Kit | Friction | Steel Plate | Steel Kit | Band | Solenoid Kit | Solenoid EPC | Solenoid TCC | Pump | Shaft | Drum | Valve body | Torque converter | Hub | Piston | Piston Kit | Planetary Gear | Filter | Gasket | Bushing | Seal | Bearing | Pressure Plate | Stator | Differential | Retainer | Inhibitor Switch | Instruction manual | TOOLS & ACCESORIES | Sensor
-
-
- Adapter, Adapters, Grommet Valvebody
- Bands, Brake band, Lining
- Bearings, brg, Mainbearing
- Bushings, Bush,
- Casing, casings, cases
- Case Covers, Cover, Dust Cover,
- Chains,
- Conductor Plates, Conducter Plate
- Connectors, loom
- Right Axle Seal, Seal Left Axle, Left Axle Seal, Seal Right Axle Shaft seal, Seal Drive Shaft, Seal MC Drive Shaft, Seal MC Drive, Axle Seal Left, seal axle, Seal Drive Shaft, Seal 4WD Left Axle, Axle Seal
- Drums, Contender Drum, Drum with Bearing, Reverse Drum, Drum Part
- Electrics, Electric, Electronic, Electronic Shift, Electronics, Pin Wiring, Relay Control Switch, Neutral Relay, Main Relay
- Filters, Filter Cartridges, Filter Cartridge, Oil Pan Filter, Inlet, Filter Kit
- Flanges, Drum Flanges, Drum Flange, Flange Yokes, Flange Yoke, Flange Kit, Rear Flange Kit, Yoke, Slip Yoke, Yokes, Flange
- Friction Discs, Frictions, fric, Friction Disc, Friction, Friction Plate, Friction Ring, fric., Clutch Plate, Friction Lining
- Friction kits, friction pack, friction set, High Energy Clutch Friction Module, Friction clutch
- Gaskets, gsk, gskt, , Cover Gasket, Cover Gaskets, Case Gasket, Case Gaskets, Filter Gasket,Filter Gaskets
- Gasket Pan, Pan Gaskets, Pan gasket, Filter Gasket,Filter Gaskets
- Housings
- manuals, Technical manual, Repair manual, service manual, Manual, VIDEO & AUDIO, tapes
- Lever, Levers, Lever Control Rod, Knob, Lever Pin, Lever Collar, SHIFT LINKAGE, Linkage Rod, Linkage, Park Pawl, Rod
- Modulators, Reverse Modulator, Vacuum modulator
- Nuts, Hex Nut, Hex Nuts, adjustment nut, band adjustment
- o-ring, o ring, 0ring, 0-ring, 0 ring, ORing, Ring, O-Rings, o-ring, O'Ring
- Output Shafts, Carrier Output Shaft, SHAFT OUTPUT
- ohk, OHK kit, Overhauls, mok, Overhaul kit, Masterkit, Master kit, Master Overhaul, Repair package, Overhaul, Rebuild kit, Master Rebuild, Super Rebuild Bundle, Banner Kit, SUPER KIT, SUPERIOR KIT
- Pans, Crankcase, Oil Pan
- Piston Pins, Servo Pin, Piston Pin, Band Pin, Retaining Pin, Retaining Pins
- Planetary Gears, Planetary Gear Set, Planetary Gear Sets, Planet, Planetary Assembly, Planetary Component, Reaction Carrier, Planet
- Pressure Plates, Apply Plate, Backing Plate, Backing Plates, Backplate, Ret Plate, Dish Plate, Press Plate
- Pumps, Rotor, Vane, Vanes, Kit Pump Vane/Ring
- Regulators, Main Pressure Regulator, Main Pressure Reg, Pressure Regulator, Forward Regulator, Secondary Regulator, Pressure Reg, Press Reg
- Regulator Valves
- Repair Kit, Kit Case Repair,
- Seals, Metal clad seal, Lip Seals, Connector Hole Seal, Lip Seal, Main Seal, Radial Lip Seal, Main Seal, Manual Seal, Oil Feed Seal, Side Cover Seal, Seal Cooler, Seal Oil Cooler, Case Seal
- Pump seal
- Cap,
- solenoid, Shift Solenoid, Kickdown Solenoid, Control Solenoid Support, Solenoid Retainer, Interlock Solenoid, Solenoid Switch
- EPC, Pressure Solenoid, Pressure Control Solenoid, Pressure Solenoid, PWM solenoid, Pressure Regulator Solenoid
- Solenoid package, solenoids, Solenoid Retainer, Solenoid Kit, pack, Solenoid Upgrade Kit, Solenoid Set, Shift Solenoid Upgrade Kit, Shift Solenoid Kit Set
- spragg, Sprags, Mechanical Diode, Sprag Assembly, Sprag Cartridge, One Way Clutches, One Way Clutch, Roller Clutches, Roller Clutch, Low/Rev Diode, Retaining Plates, Retaining Plate, Accordion Spring, OWC
- Stators
- Steel Kits, Steel Set Kit, Steel Clutch Plate Kit, Steel kit, clutch steel, clutch steels, Steel set, steel pack, module kit, Steel Plate Clutch Kit, Steel Plate Kit, Steel Plate Module, Steel Plate Set, Steel Module
- Steel Plates, steel, Steels, steel disk
- Tool kits, Alignments, Alignment, Reamers, Reamer, Tool kit, Tool, Pressure Gauge, Clutch Aligning Tool, Clutch Removal Tool, Clutch Tool Supplement, Kit Installer, Air Test Plate, ADJUSTMENT TOOL, Thread Tap, Remover
- converter, t.converter,
- Throttle Valve, Timing Valve, Operating, Relief Valve, Safety Valve, Control Valve, AFL Valve, Limit Valve, Actuator Feed Limit Valve, AFL Valve
- VB plate, Valve body plates, Valve body plate, ValveBody, V/Body, valve-body, v body, v-body, v/b, Orifice, Hydraulic control unit, HCU
- Overlap Control Valve Kit, Pressure Regulator Valve, Switch Valve Plug, Actuator Feed Limit
Technical issues and repair guidelines
Before covering 200 thousand kilometers these automatic gearboxes get in repair services for 2 reason
1. The clutch drum К1
Due to construction peculiarities of the 722.7 unit and its valve body (VB), at one of the phases of clogging and aging of the 722.7 electrics transmitted excessive pressure on this pack damages the metal of the drum with the piston or pulls out the closing ring, that leads to slipping and necessity for change of the entire clutch cover K1. Preventive measures include well-timed cleaning of the VB unit, or well-timed change of the TC lock-up clutch after gearbox travels 150-200 thousand kilometers.
2.Valve body electronic plate
For proper diagnostics and repair estimation, it is necessary to obtain error codes. Change of the board sensors or wiring of solenoids demands classification of the specialist and programming capabilities for encoding the plate for VIN of the car. Mercedes electronic boards are sensitive to the water, temperature difference, metal chips in oil. Each time diagnostics detects various causes of abnormal operation. The minor repair helps to delay the preventive repair for several years by means of cleaning\washing of the VB unit, repair of the electric plate with broken sensors. Operation with overheated oil damages the electronic plate extremely fast.
Instruction manuals and useful links Suggest your link
| Link type | Source | Description |
|---|---|---|
| www | www.at-manuals.com | Electronic and Solenoids scheme |