Allison 8000/9000 Transmission parts, repair guidelines, problems, manuals
Transmission general data
Number of gears | Transmission Type | Torque (Nm) | ATF (full capacity) L | ATF type |
---|---|---|---|---|
6 , 8 | AT | 3600/12200 | 79 | Allison TES 295 |
These advanced units were designed for operation under the most severe conditions and they can be applied in vehicles with the power capacity of 1200 hp (for 8000 Series) and 2600 hp. Allison 8000 Series transmissions can have up to 6 forward gears and 1 R-gear, while the 9000 Series units can have up to 8 forward gears (6 gears for commercial vehicles) and up to 2 R-gears. These transmissions are notable for high performance characteristics and reliability. Moreover, they can be equipped with hydraulic retarder-brakes, 2 PTO mechanisms, and flange adapters.
What are you looking for?
Overhaul Kit | Friction Kit | Friction | Steel Plate | Steel Kit | Band | Solenoid Kit | Solenoid EPC | Solenoid TCC | Pump | Shaft | Drum | Valve body | Torque converter | Hub | Piston | Piston Kit | Planetary Gear | Filter | Gasket | Bushing | Seal | Bearing | Pressure Plate | Stator | Differential | Retainer | Inhibitor Switch | Instruction manual | TOOLS & ACCESORIES | Sensor
-
-
- Bearings, brg, Mainbearing
- Input Carriers, Input Carrier, Carrier Assy, CARRIER-CR, CARRIER-MD,
- Case Covers, Cover, Dust Cover,
- Flexplates, Flex plate, Driveplate, Drive plate, D/Plate, Flexplate
- Drums, Contender Drum, Drum with Bearing, Reverse Drum, Drum Part
- Filters, Filter Cartridges, Filter Cartridge, Oil Pan Filter, Inlet, Filter Kit
- Flanges, Drum Flanges, Drum Flange, Flange Yokes, Flange Yoke, Flange Kit, Rear Flange Kit, Yoke, Slip Yoke, Yokes, Flange
- Flywheel Shim, Dual Mass Fly Wheel, Fly Wheel, Dual Mass Flywheel
- Friction Discs, Frictions, fric, Friction Disc, Friction, Friction Plate, Friction Ring, fric., Clutch Plate, Friction Lining
- Gaskets, gsk, gskt, , Cover Gasket, Cover Gaskets, Case Gasket, Case Gaskets, Filter Gasket,Filter Gaskets
- Housings
- Hubs, Hub Insert
- manuals, Technical manual, Repair manual, service manual, Manual, VIDEO & AUDIO, tapes
- Magnets
- Nuts, Hex Nut, Hex Nuts, adjustment nut, band adjustment
- o-ring, o ring, 0ring, 0-ring, 0 ring, ORing, Ring, O-Rings, o-ring, O'Ring
- Pinions, Pinion Gear, Pinion Pin, Pinion Gear Shaft,
- Pistons, Apply Piston, Pack Piston, High Piston, Damper Piston, Piston Damper, Piston Plate, Interm. Servo Pist, Piston Seals, Piston Seal Ring, Piston Seal Rings, Piston Seal, Piston Cover, Piston Covers, Rear Servo, servo piston, Piston Retainer, Piston Retainers, Servo kit, Super Servo, servo, Shift Pison
- Pumps, Rotor, Vane, Vanes, Kit Pump Vane/Ring
- Retainers, Spring Retainer, Plug Retainer, Bearing Retainer
- Seals, Metal clad seal, Lip Seals, Connector Hole Seal, Lip Seal, Main Seal, Radial Lip Seal, Main Seal, Manual Seal, Oil Feed Seal, Side Cover Seal, Seal Cooler, Seal Oil Cooler, Case Seal
- Shafts
- Sleeves, SLEEE, Ground Sleeve, Overlap Control Sleeve, Seal Ring Sleeve, Repair Sleeve, Regulator Sleeve, Modulator Sleeve, Pressure Sleeve, Piston Sleeve, Pinion Repair Sleeve, Damper Sleeve, Bore Sleeve, Boost Sleeve
- solenoid, Shift Solenoid, Kickdown Solenoid, Control Solenoid Support, Solenoid Retainer, Interlock Solenoid, Solenoid Switch
- Speedometer Driven Gear, Speedo
- Stators
- Steel Plates, steel, Steels, steel disk
- Sun Gears, Sungear, Sungears, Sun Gear Retaining Ring, Final Drives, Final Drive, FinalDrive, SUN
- Washer, Washers, T/Washers, Thrust Washers, Selective Washers, Kit Washer, Drive Sprockets, Driven Sprockets, Drive Sprocket, Thrust Kit, Washer kit,
- converter, t.converter,
- Tubes, Oil Tube
- Turbines