BW35 Transmission parts, repair guidelines, problems, manuals
Transmission general data
| Number of gears | Transmission Type | Drive | ATF (full capacity) L | ATF (change) L | ATF type |
|---|---|---|---|---|---|
| 3 | AT | RWD | 8,2 | 4,5 | Type F Fluid, Dexron II |
The
BW-35 is an A/T manufactured by the BorgWarner in the 1950s particularly for
engines with the capacity of less than 200 cu.in. The modification 35 is a
3-speed A/T coupled to the engine by a three-element torque converter.
What are you looking for?
Overhaul Kit | Friction Kit | Friction | Steel Plate | Steel Kit | Band | Solenoid Kit | Solenoid EPC | Solenoid TCC | Pump | Shaft | Drum | Valve body | Torque converter | Hub | Piston | Piston Kit | Planetary Gear | Filter | Gasket | Bushing | Seal | Bearing | Pressure Plate | Stator | Differential | Retainer | Inhibitor Switch | Instruction manual | TOOLS & ACCESORIES | Sensor
-
-
- Accumulators, Accumulator Piston, Acummalator Kit, Accumulator Piston Kit
- Oils, NS2, NS-2, ATF, Oil
- Bands, Brake band, Lining
- Strut, Band Struts, Struts, Anchor Pin, Band Anchor
- Bearings, brg, Mainbearing
- Bushings, Bush,
- Casing, casings, cases
- Chains,
- Circlips, Clip, Detent Cable Clip, Line Clip, Linkage Clip, Retainer Clip, Snap Ring, Snap Rings, Retaining Ring, Cover Retaining Ring, Retaining Ring, Circlip Kit, Kit Circlips, Kit Snap Ring, Kit Snap Ring,
- Coolers, Oil Cooler, Heat Exchange, Heat Exchanger
- Differentials, Differential Carrier, Differential Carriers, Diff, Diff., Diff Housing Carrier
- Right Axle Seal, Seal Left Axle, Left Axle Seal, Seal Right Axle Shaft seal, Seal Drive Shaft, Seal MC Drive Shaft, Seal MC Drive, Axle Seal Left, seal axle, Seal Drive Shaft, Seal 4WD Left Axle, Axle Seal
- Flexplates, Flex plate, Driveplate, Drive plate, D/Plate, Flexplate
- Drums, Contender Drum, Drum with Bearing, Reverse Drum, Drum Part
- Electrics, Electric, Electronic, Electronic Shift, Electronics, Pin Wiring, Relay Control Switch, Neutral Relay, Main Relay
- Extn Hsg, Extn.Hsg, Extensions, Extension, Overdrive Housing, TAIL HOUSING, TAIL EXTENSION
- Filters, Filter Cartridges, Filter Cartridge, Oil Pan Filter, Inlet, Filter Kit
- Friction Discs, Frictions, fric, Friction Disc, Friction, Friction Plate, Friction Ring, fric., Clutch Plate, Friction Lining
- Gaskets, gsk, gskt, , Cover Gasket, Cover Gaskets, Case Gasket, Case Gaskets, Filter Gasket,Filter Gaskets
- Gasket Pan, Pan Gaskets, Pan gasket, Filter Gasket,Filter Gaskets
- Governors
- loom, Harnesses, Line Connector, Wiring, Cover Wiring, Cable, Signal Cable, Cable, Power Cord
- Inhibitor switches, Inhib.Swtch, Range Selector Switch, Selector, Range Switch, Position Switch, Gear Selector, ISM
- Input Shafts, Shaft input, Shaft Input/Main, Inputshaft
- manuals, Technical manual, Repair manual, service manual, Manual, VIDEO & AUDIO, tapes
- o-ring, o ring, 0ring, 0-ring, 0 ring, ORing, Ring, O-Rings, o-ring, O'Ring
- ohk, OHK kit, Overhauls, mok, Overhaul kit, Masterkit, Master kit, Master Overhaul, Repair package, Overhaul, Rebuild kit, Master Rebuild, Super Rebuild Bundle, Banner Kit, SUPER KIT, SUPERIOR KIT
- Pans, Crankcase, Oil Pan
- Pipes, Modulator Pipe, Inlet Pipe, feed Pipe, oil pipe
- Pistons, Apply Piston, Pack Piston, High Piston, Damper Piston, Piston Damper, Piston Plate, Interm. Servo Pist, Piston Seals, Piston Seal Ring, Piston Seal Rings, Piston Seal, Piston Cover, Piston Covers, Rear Servo, servo piston, Piston Retainer, Piston Retainers, Servo kit, Super Servo, servo, Shift Pison
- Plugs, Plug Adapter, Intermediate Plugs, Intermediate Plug, Bore Plug, Bore Plugs, Valve Bore Plugs, Valve Bore Plug
- Pressure Plates, Apply Plate, Backing Plate, Backing Plates, Backplate, Ret Plate, Dish Plate, Press Plate
- Pumps, Rotor, Vane, Vanes, Kit Pump Vane/Ring
- Seals, Metal clad seal, Lip Seals, Connector Hole Seal, Lip Seal, Main Seal, Radial Lip Seal, Main Seal, Manual Seal, Oil Feed Seal, Side Cover Seal, Seal Cooler, Seal Oil Cooler, Case Seal
- Pump seal
- Seal Rings, Seal Ring, Sealing Rings, Piston Seal, S/Ring, SEALING RINGS S/Ring, Accumalator Seals
- Shafts
- Shims, Endplay Shims, End-play Shims, End-play Shim, Endplay Shim
- spragg, Sprags, Mechanical Diode, Sprag Assembly, Sprag Cartridge, One Way Clutches, One Way Clutch, Roller Clutches, Roller Clutch, Low/Rev Diode, Retaining Plates, Retaining Plate, Accordion Spring, OWC
- Springs, Wave Spring, Spring Adjuster, Spring Disc, Torsion Spring, Return Spring, Piston Spring, Damper Spring, Damper Springs, Control Spring, Detent Spring, Drum Spring, Limit Spring, Return Sprng, Diaphragm Springs, Diaphragm Spring
- Stators
- Steel Kits, Steel Set Kit, Steel Clutch Plate Kit, Steel kit, clutch steel, clutch steels, Steel set, steel pack, module kit, Steel Plate Clutch Kit, Steel Plate Kit, Steel Plate Module, Steel Plate Set, Steel Module
- Steel Plates, steel, Steels, steel disk
- Supports, Centre Supp Rebuilt, central support. support central
- Manifolds, Switch Manifold, Switch Manifolds, Pressure Switch Manifold, Pressure Switch Manifolds, Switch, Manifold
- Washer, Washers, T/Washers, Thrust Washers, Selective Washers, Kit Washer, Drive Sprockets, Driven Sprockets, Drive Sprocket, Thrust Kit, Washer kit,
- converter, t.converter,
- Tubes, Oil Tube
- Turbines
Technical issues and repair guidelines
Engine power is converted into hydrokinetic energy and this provides smooth application or driving torque. This transmission has 3-forward and 1- reverse transmission ratio. It was constructed for operation with Type-F oil, which is not so popular today as Dexron.
The hydraulically operated control unit includes a valve location and a pump activated by the engine. The automatic gearbox includes a planetary set having 2 center gears, 3 sets of 3-epicyclic gears which can be found in a planet gear holder and follower gear.
Instruction manuals and useful links Suggest your link
| Link type | Source | Description |
|---|---|---|
| volvoenthusiastsclub | Repair manual BW35 | |
| drive.google.com | Manual BW35 |