01M Transmission parts, repair guidelines, problems, manuals
Transmission general data
Number of gears | Transmission Type | Drive | Torque (Nm) | ATF (full capacity) L | ATF (change) L | ATF type |
---|---|---|---|---|---|---|
4 | AT | FWD | 200 | 6,5 | 3,8 | LT 71141, 75W90 GL4 |
What are you looking for?
Overhaul Kit | Friction Kit | Friction | Steel Plate | Steel Kit | Band | Solenoid Kit | Solenoid EPC | Solenoid TCC | Pump | Shaft | Drum | Valve body | Torque converter | Hub | Piston | Piston Kit | Planetary Gear | Filter | Gasket | Bushing | Seal | Bearing | Pressure Plate | Stator | Differential | Retainer | Inhibitor Switch | Instruction manual | TOOLS & ACCESORIES | Sensor
Which cars run with this gearbox?
Brand | Model | Year | Type | Engine |
---|---|---|---|---|
Audi | A3 | 00-06 | 4 SP F/4WD | L4 1.6L 1.8L 1.9L |
Seat | TOLEDO | 96-01 | 4 SP FWD | L4 1.6L 1.8L 2.0L |
Volkswagen | BEETLE | 98-10 | 4 SP FWD | L4 1.4L 1.6L 1.8L 1.9L 2.0L |
Volkswagen | CABRIO | 95-01 | 4 SP FWD | L4 2.0L |
Volkswagen | GOLF/GTI | 95-06 | 4 SP FWD | L4 1.8L 2.0L 1.9L DIESEL |
Volkswagen | JETTA | 93-01 | 4 SP FWD | L4 1.8L 1.9 2.0L V6 2.8L |
Volkswagen | JETTA | 02-05 | 4 SP FWD | L4 2.0L 1.9L DIESEL |
Volkswagen | PASSAT | 95-11 | 4 SP FWD | L4 1.9L 2.0L V6 2.8L |
-
-
- Adapter, Adapters, Grommet Valvebody
- Oils, NS2, NS-2, ATF, Oil
- Bearings, brg, Mainbearing
- Cover Bolt, Cover Bolts, Mounting Bolt, Mounting Bolts, Pan Bolt, Pan Bolts, stud, studs, Split Pin
- Booster, Boosters, Boost Regulator, Boost Spring, Boost Valve, Lockup Boost, Booster kit, Kit Boost, Kit Boost Valve
- Bushings, Bush,
- Casing, casings, cases
- Case Covers, Cover, Dust Cover,
- Chains,
- Check Balls, Checkball, Checkballs, Balls, ball
- Circlips, Clip, Detent Cable Clip, Line Clip, Linkage Clip, Retainer Clip, Snap Ring, Snap Rings, Retaining Ring, Cover Retaining Ring, Retaining Ring, Circlip Kit, Kit Circlips, Kit Snap Ring, Kit Snap Ring,
- Connectors, loom
- Coolers, Oil Cooler, Heat Exchange, Heat Exchanger
- CrownWheel, c/w
- Dampers, Damper Assembly, Damper
- Differentials, Differential Carrier, Differential Carriers, Diff, Diff., Diff Housing Carrier
- Dipsticks, dip-stick, dip-sticks, Dip Stick
- Drums, Contender Drum, Drum with Bearing, Reverse Drum, Drum Part
- TCMs, transmission control module, TCU, TCM, Computer, Circuit Board, Control Module, Control Unit, Hardware
- Electrics, Electric, Electronic, Electronic Shift, Electronics, Pin Wiring, Relay Control Switch, Neutral Relay, Main Relay
- End Plugs, Tail Plug, Tail Plugs, Tailplug, Tailplugs
- Filters, Filter Cartridges, Filter Cartridge, Oil Pan Filter, Inlet, Filter Kit
- Flanges, Drum Flanges, Drum Flange, Flange Yokes, Flange Yoke, Flange Kit, Rear Flange Kit, Yoke, Slip Yoke, Yokes, Flange
- Friction Discs, Frictions, fric, Friction Disc, Friction, Friction Plate, Friction Ring, fric., Clutch Plate, Friction Lining
- Friction kits, friction pack, friction set, High Energy Clutch Friction Module, Friction clutch
- Shields, Shield
- Gaskets, gsk, gskt, , Cover Gasket, Cover Gaskets, Case Gasket, Case Gaskets, Filter Gasket,Filter Gaskets
- Gasket Pan, Pan Gaskets, Pan gasket, Filter Gasket,Filter Gaskets
- loom, Harnesses, Line Connector, Wiring, Cover Wiring, Cable, Signal Cable, Cable, Power Cord
- Hubs, Hub Insert
- manuals, Technical manual, Repair manual, service manual, Manual, VIDEO & AUDIO, tapes
- Nuts, Hex Nut, Hex Nuts, adjustment nut, band adjustment
- o-ring, o ring, 0ring, 0-ring, 0 ring, ORing, Ring, O-Rings, o-ring, O'Ring
- Output Shafts, Carrier Output Shaft, SHAFT OUTPUT
- ohk, OHK kit, Overhauls, mok, Overhaul kit, Masterkit, Master kit, Master Overhaul, Repair package, Overhaul, Rebuild kit, Master Rebuild, Super Rebuild Bundle, Banner Kit, SUPER KIT, SUPERIOR KIT
- Pans, Crankcase, Oil Pan
- Piston Pins, Servo Pin, Piston Pin, Band Pin, Retaining Pin, Retaining Pins
- Pinions, Pinion Gear, Pinion Pin, Pinion Gear Shaft,
- Pipes, Modulator Pipe, Inlet Pipe, feed Pipe, oil pipe
- Pistons, Apply Piston, Pack Piston, High Piston, Damper Piston, Piston Damper, Piston Plate, Interm. Servo Pist, Piston Seals, Piston Seal Ring, Piston Seal Rings, Piston Seal, Piston Cover, Piston Covers, Rear Servo, servo piston, Piston Retainer, Piston Retainers, Servo kit, Super Servo, servo, Shift Pison
- Piston Kits, Piston Complete, Piston part, Piston Sets, Piston Set
- Planetary Gears, Planetary Gear Set, Planetary Gear Sets, Planet, Planetary Assembly, Planetary Component, Reaction Carrier, Planet
- Plugs, Plug Adapter, Intermediate Plugs, Intermediate Plug, Bore Plug, Bore Plugs, Valve Bore Plugs, Valve Bore Plug
- Plungers, plung, Control Plunger, Control Plungers, Apply Control Plunger, Modulator Plunger
- Pressure Plates, Apply Plate, Backing Plate, Backing Plates, Backplate, Ret Plate, Dish Plate, Press Plate
- Pulleys, Primary Pulley, Primary Unit, Secondary Pulley, Secondary shaft, Secondary Unit, Primary + Secondary Units, (drive)Pulley
- Pumps, Rotor, Vane, Vanes, Kit Pump Vane/Ring
- Regulators, Main Pressure Regulator, Main Pressure Reg, Pressure Regulator, Forward Regulator, Secondary Regulator, Pressure Reg, Press Reg
- Regulator Valves
- Repair Kit, Kit Case Repair,
- Retainers, Spring Retainer, Plug Retainer, Bearing Retainer
- Seals, Metal clad seal, Lip Seals, Connector Hole Seal, Lip Seal, Main Seal, Radial Lip Seal, Main Seal, Manual Seal, Oil Feed Seal, Side Cover Seal, Seal Cooler, Seal Oil Cooler, Case Seal
- Pinion Seals
- Pump seal
- Cap,
- Seal Rings, Seal Ring, Sealing Rings, Piston Seal, S/Ring, SEALING RINGS S/Ring, Accumalator Seals
- Sensors
- Sump modification kit
- Shafts
- Reprogramming Kit, Kit Reprogram, Reprogram Competition, Kit Shift, Kit Auto Shift, Kit Stick Shift, Shift Correction Kit
- Shims, Endplay Shims, End-play Shims, End-play Shim, Endplay Shim
- Sleeves, SLEEE, Ground Sleeve, Overlap Control Sleeve, Seal Ring Sleeve, Repair Sleeve, Regulator Sleeve, Modulator Sleeve, Pressure Sleeve, Piston Sleeve, Pinion Repair Sleeve, Damper Sleeve, Bore Sleeve, Boost Sleeve
- solenoid, Shift Solenoid, Kickdown Solenoid, Control Solenoid Support, Solenoid Retainer, Interlock Solenoid, Solenoid Switch
- EPC, Pressure Solenoid, Pressure Control Solenoid, Pressure Solenoid, PWM solenoid, Pressure Regulator Solenoid
- Solenoid package, solenoids, Solenoid Retainer, Solenoid Kit, pack, Solenoid Upgrade Kit, Solenoid Set, Shift Solenoid Upgrade Kit, Shift Solenoid Kit Set
- Speed Sensors, Output Sensor, Input sensor, Reluctor, Shaft Sensor, Speed Sender, Sensor Input, Sensor Output, Sensor Input / Output, TURBINE SPEED, INPUT SPEED, VEHICLE SPEED
- spragg, Sprags, Mechanical Diode, Sprag Assembly, Sprag Cartridge, One Way Clutches, One Way Clutch, Roller Clutches, Roller Clutch, Low/Rev Diode, Retaining Plates, Retaining Plate, Accordion Spring, OWC
- Springs, Wave Spring, Spring Adjuster, Spring Disc, Torsion Spring, Return Spring, Piston Spring, Damper Spring, Damper Springs, Control Spring, Detent Spring, Drum Spring, Limit Spring, Return Sprng, Diaphragm Springs, Diaphragm Spring
- Stators
- Steel Kits, Steel Set Kit, Steel Clutch Plate Kit, Steel kit, clutch steel, clutch steels, Steel set, steel pack, module kit, Steel Plate Clutch Kit, Steel Plate Kit, Steel Plate Module, Steel Plate Set, Steel Module
- Steel Plates, steel, Steels, steel disk
- Sun Gears, Sungear, Sungears, Sun Gear Retaining Ring, Final Drives, Final Drive, FinalDrive, SUN
- Sure, Sure Cure
- Manifolds, Switch Manifold, Switch Manifolds, Pressure Switch Manifold, Pressure Switch Manifolds, Switch, Manifold
- Washer, Washers, T/Washers, Thrust Washers, Selective Washers, Kit Washer, Drive Sprockets, Driven Sprockets, Drive Sprocket, Thrust Kit, Washer kit,
- Tool kits, Alignments, Alignment, Reamers, Reamer, Tool kit, Tool, Pressure Gauge, Clutch Aligning Tool, Clutch Removal Tool, Clutch Tool Supplement, Kit Installer, Air Test Plate, ADJUSTMENT TOOL, Thread Tap, Remover
- converter, t.converter,
- Tubes, Oil Tube
- Throttle Valve, Timing Valve, Operating, Relief Valve, Safety Valve, Control Valve, AFL Valve, Limit Valve, Actuator Feed Limit Valve, AFL Valve
- VB plate, Valve body plates, Valve body plate, ValveBody, V/Body, valve-body, v body, v-body, v/b, Orifice, Hydraulic control unit, HCU
- Overlap Control Valve Kit, Pressure Regulator Valve, Switch Valve Plug, Actuator Feed Limit
- Oversized Valve, flow control, Oversized Safety, Oversized, Flow Control, Valve pump flow control, Pump flow control valve, Oversized Pump Flow Control
Technical issues and repair guidelines
One of the peculiarities of the 01M transmission lies in the transversal positioning of the unit. Therefore, VAG engineers also had to add a differential with a separate lubrication system (i.e. oil for it is tested and replaced separately).Gasket and seal repair kit (Overhaul kit) for the 01M is frequently ordered for the transmission repair. Rebuilding procedures, especially when there is burnt oil, require a full set of the friction components.
The list of 01M vulnerabilities includes the following:
- The rubber hardens and poorly endures pressure, especially in winter. Older vehicles and overheated automatic gearboxes have the full set of rubber-coated pistons replaced in them.
- The drum 3-4 may become worn out due to breaking of the basket along the axle of the shaft.
- The green front drum washer - plastic sliding bearing - melts or becomes brittle due to the temperature and lateral pressure effect.
- It is believed that 8-10 years is the average normal lifespan for all 01M-01N electrical components, including sensors. After this term, the resistance of its wiring starts to increase, the channel gets worn out, the characteristics of the valve closure change, and the computer "rejects" them.
- The Valve Body requires regular cleaning. For vehicles that covered over 150-200 thousand km this procedure is a “must”. (As well as Torque Converter rebuilding)
- ATF contamination comes from the Torque Converter and is a result of the dust flow from friction linings and worn out bearing washer. Contaminated ATF blocks channels and corrodes metal of these channels at some most loaded valves of the Hydraulic unit.
Instruction manuals and useful links Suggest your link
Link type | Source | Description |
---|---|---|
www | Wikipedia | Volkswagen 01M transmission |
www | kansascitytdi.com | 01M Transmission Removal and Reinstallation |
www | kansascitytdi.com | 01M Valve Body Removal and Reinstalation |
www | kansascitytdi.com | 01M or 01P Valve Body Repair |
just-t4s.co.uk | 01M, 01N, 01P UNCONTROLLABLE HARSH 1-2 UPSHIFT | |
www | kansascitytdi.com | 01M Filter change |
google.com | Repair manual 01m transmission | |
europeantransmissions.com | 01M/01N/01P 1996-2000 OBD-II CODE DEFINITIONS |