45RFE Transmission parts, repair guidelines, problems, manuals
C45RFE
Transmission general data
| Number of gears | Transmission Type | Drive | ATF (full capacity) L | ATF (change) L | ATF type |
|---|---|---|---|---|---|
| 4 | AT | RWD | 11 | 5 | Mopar ATF+4 |
What are you looking for?
Overhaul Kit | Friction Kit | Friction | Steel Plate | Steel Kit | Band | Solenoid Kit | Solenoid EPC | Solenoid TCC | Pump | Shaft | Drum | Valve body | Torque converter | Hub | Piston | Piston Kit | Planetary Gear | Filter | Gasket | Bushing | Seal | Bearing | Pressure Plate | Stator | Differential | Retainer | Inhibitor Switch | Instruction manual | TOOLS & ACCESORIES | Sensor
Which cars run with this gearbox?
| Brand | Model | Year | Type | Engine |
|---|---|---|---|---|
| Dodge | DURANGO | 00-02 | 4 SP R/4WD | V8 4.7L |
| Dodge | PICKUP/DAKOTA | 00-02 | 4 SP R/4WD | V8 4.7L |
| Dodge | PICKUP/RAM 1500 | 02-05 | 4 SP R/4WD | V6 3.7L V8 4.7L |
| JEEP | GRAND CHEROKEE | 99-00 | 4 SP R/4WD | V8 4.7L |
| JEEP | LIBERTY | 2 | 4 SP R/4WD | V6 3.7L |
-
-
- Accumulators, Accumulator Piston, Acummalator Kit, Accumulator Piston Kit
- Oils, NS2, NS-2, ATF, Oil
- Bands, Brake band, Lining
- Bearings, brg, Mainbearing
- Booster, Boosters, Boost Regulator, Boost Spring, Boost Valve, Lockup Boost, Booster kit, Kit Boost, Kit Boost Valve
- Bushings, Bush,
- Case Covers, Cover, Dust Cover,
- Drums, Contender Drum, Drum with Bearing, Reverse Drum, Drum Part
- Electrics, Electric, Electronic, Electronic Shift, Electronics, Pin Wiring, Relay Control Switch, Neutral Relay, Main Relay
- Filters, Filter Cartridges, Filter Cartridge, Oil Pan Filter, Inlet, Filter Kit
- Friction Discs, Frictions, fric, Friction Disc, Friction, Friction Plate, Friction Ring, fric., Clutch Plate, Friction Lining
- Friction kits, friction pack, friction set, High Energy Clutch Friction Module, Friction clutch
- Shields, Shield
- Gaskets, gsk, gskt, , Cover Gasket, Cover Gaskets, Case Gasket, Case Gaskets, Filter Gasket,Filter Gaskets
- Gasket Pan, Pan Gaskets, Pan gasket, Filter Gasket,Filter Gaskets
- Governors
- loom, Harnesses, Line Connector, Wiring, Cover Wiring, Cable, Signal Cable, Cable, Power Cord
- Housings
- Hubs, Hub Insert
- Input Shafts, Shaft input, Shaft Input/Main, Inputshaft
- manuals, Technical manual, Repair manual, service manual, Manual, VIDEO & AUDIO, tapes
- o-ring, o ring, 0ring, 0-ring, 0 ring, ORing, Ring, O-Rings, o-ring, O'Ring
- O/D,
- ohk, OHK kit, Overhauls, mok, Overhaul kit, Masterkit, Master kit, Master Overhaul, Repair package, Overhaul, Rebuild kit, Master Rebuild, Super Rebuild Bundle, Banner Kit, SUPER KIT, SUPERIOR KIT
- Pans, Crankcase, Oil Pan
- Pistons, Apply Piston, Pack Piston, High Piston, Damper Piston, Piston Damper, Piston Plate, Interm. Servo Pist, Piston Seals, Piston Seal Ring, Piston Seal Rings, Piston Seal, Piston Cover, Piston Covers, Rear Servo, servo piston, Piston Retainer, Piston Retainers, Servo kit, Super Servo, servo, Shift Pison
- Piston Kits, Piston Complete, Piston part, Piston Sets, Piston Set
- Planetary Gears, Planetary Gear Set, Planetary Gear Sets, Planet, Planetary Assembly, Planetary Component, Reaction Carrier, Planet
- Plugs, Plug Adapter, Intermediate Plugs, Intermediate Plug, Bore Plug, Bore Plugs, Valve Bore Plugs, Valve Bore Plug
- Pressure Plates, Apply Plate, Backing Plate, Backing Plates, Backplate, Ret Plate, Dish Plate, Press Plate
- Pressure Sensors, Sensor Gov Pressure
- Pumps, Rotor, Vane, Vanes, Kit Pump Vane/Ring
- Repair Kit, Kit Case Repair,
- Seals, Metal clad seal, Lip Seals, Connector Hole Seal, Lip Seal, Main Seal, Radial Lip Seal, Main Seal, Manual Seal, Oil Feed Seal, Side Cover Seal, Seal Cooler, Seal Oil Cooler, Case Seal
- Pump seal
- Sensors
- Seperator Plate, V/B Separater Plate, Seperater Plate, sep plate, Spacer, Spacers
- Sump modification kit
- Reprogramming Kit, Kit Reprogram, Reprogram Competition, Kit Shift, Kit Auto Shift, Kit Stick Shift, Shift Correction Kit
- solenoid, Shift Solenoid, Kickdown Solenoid, Control Solenoid Support, Solenoid Retainer, Interlock Solenoid, Solenoid Switch
- Solenoid Blocks, sol block, Brass Contact,
- Solenoid package, solenoids, Solenoid Retainer, Solenoid Kit, pack, Solenoid Upgrade Kit, Solenoid Set, Shift Solenoid Upgrade Kit, Shift Solenoid Kit Set
- Speed Sensors, Output Sensor, Input sensor, Reluctor, Shaft Sensor, Speed Sender, Sensor Input, Sensor Output, Sensor Input / Output, TURBINE SPEED, INPUT SPEED, VEHICLE SPEED
- spragg, Sprags, Mechanical Diode, Sprag Assembly, Sprag Cartridge, One Way Clutches, One Way Clutch, Roller Clutches, Roller Clutch, Low/Rev Diode, Retaining Plates, Retaining Plate, Accordion Spring, OWC
- Stators
- Steel Kits, Steel Set Kit, Steel Clutch Plate Kit, Steel kit, clutch steel, clutch steels, Steel set, steel pack, module kit, Steel Plate Clutch Kit, Steel Plate Kit, Steel Plate Module, Steel Plate Set, Steel Module
- Steel Plates, steel, Steels, steel disk
- Switch Valves
- Tool kits, Alignments, Alignment, Reamers, Reamer, Tool kit, Tool, Pressure Gauge, Clutch Aligning Tool, Clutch Removal Tool, Clutch Tool Supplement, Kit Installer, Air Test Plate, ADJUSTMENT TOOL, Thread Tap, Remover
- converter, t.converter,
- Turbines
- Throttle Valve, Timing Valve, Operating, Relief Valve, Safety Valve, Control Valve, AFL Valve, Limit Valve, Actuator Feed Limit Valve, AFL Valve
- VB plate, Valve body plates, Valve body plate, ValveBody, V/Body, valve-body, v body, v-body, v/b, Orifice, Hydraulic control unit, HCU
- Overlap Control Valve Kit, Pressure Regulator Valve, Switch Valve Plug, Actuator Feed Limit
- Oversized Valve, flow control, Oversized Safety, Oversized, Flow Control, Valve pump flow control, Pump flow control valve, Oversized Pump Flow Control
Technical issues and repair guidelines
These comparatively “invincible” transmissions in most cases come to repair shops for change of the oil and filters, which are replaced with dismounting of the pan. AWD modifications of this transmission have different oil filter and pan depth.
Scheduled overhaul includes the following spare parts in repair kits:
- Kit of gaskets and seals is replaced because of worn-out rings and valve body spare parts.
- Kit of friction components
- Kit of steel discs
These 3 kits compose the Master Kit. The kit of rubber-covered pistons is also ordered in case of the transmission overheating. Worn-out bushings also get replaced quite frequently.
Problems of these automatic transmissions occur when the valve body provides insufficient quantity of ATF. Solenoids also exhaust their limited service resource, the valve body gets clogged and wears out.The pump has 3 gears which are tested for wear and damages of operating surfaces. The pump bushing is also checked for wear. The pump has some issues with the wear-out of surfaces. The reason lies in a long-term operation with contaminated oil.The rubber-coated pump cover performs functions of the pump seal. This cover gets damaged by vibrations from the worn-out torque converter lock-up. There are several modifications of this cover.
Friction components with steel discs are the first to get burnt in Overdrive and Underdrive packages.This overheating of frictions in chain order leads to overheating of the valve body itself and electronics in the block of solenoids.
Instruction manuals and useful links Suggest your link
| Link type | Source | Description |
|---|---|---|
| Valve Body Pro | 45RFE Simplifying Sol's Codes | |
| Sonnax | Valve Body Layout 45rfe | |
| Sonnax | Vacuum test 45RFE, 545RFE, 65RFE, 66RFE, 68RFE | |
| drive.google.com | Instruction 45RFE | |
| drive.google.com | Repair manual 45RFE ATSG |